Section 1: Chemical Product and Company Information
|
PRODUCT |
|
|
NUMBER: |
CAL551-950 |
|
NAME: |
CAL551-950 Batt-Mat-C™ |
|
DESCRIPTION: |
|
|
MANUFACTURER |
|
EMERGENCY TELEPHONE NUMBERS |
|
Calicorp, Inc.
629 Tandy Court
Chico,
Ca. 95973 |
|
Domestic: |
1.888.BATT.MAT |
|
|
International: |
+1.530.228.8628 |
|
|
|
|
Section 2:
Composition/Information on Ingredients
This product is not
considered a hazardous waste under the RCRA.
All ingredients are
non-regulated.
|
COMPONENT |
% |
CAS # |
EXPOSURE LIMIT |
|
Citric Acid |
> 55% |
77-92-9 |
|
|
Vermiculite |
< 20% |
1318-00-9 |
|
|
Trade secret (Not Regulated) |
< 10% |
confidential |
|
|
Bentonite Clay |
> 2% |
1302-78-9 |
|
|
Trade secret (Not Regulated) |
< 1% |
confidential |
|
|
Polyethylene Terephthalate Polymer |
bag material |
25038-59-9 |
|
Section 3: Hazards
Identification
|
Toxicity |
None Detected |
|
Medical Conditions Aggravated by
Exposure |
None Identified. |
|
Inhalation |
Possible irritation of upper
respiratory track |
|
Skin Contact |
Non-irritating |
|
Eye Contact |
Irritating |
|
Ingestion |
Possible severe gastro-intestinal
irritation and ulceration. |
Section 4: First Aid
Measures
|
Ingestion |
If conscious, immediately drink one to
two glasses of water.
Get medical attention |
|
Eyes |
Immediately flush eyes with water for
15 minutes. Call physician. |
|
Skin |
Wash with mild soap and water. |
|
Inhalation |
Remove from exposure to fresh air.
Give oxygen if breathing is difficult.
If irritation persists, obtain medical
attention. |
Section 5: Fire Fighting
Measures
|
Flash Point |
Containment fabric is flash resistant
treated |
|
Extinguishing Media |
Use extinguishing media appropriate for
surrounding fire |
|
Special Procedures |
Firefighters should wear proper
protective equipment and self-contained breathing apparatus with
full-face piece operated in positive pressure mode. |
|
Toxic Gasses Produced |
Carbon Monoxide, Carbon Dioxide |
Section 6: Accident Release
Measures
|
Steps to be taken if material is
spilled |
Wear suitable protective clothing.
Shovel into closeable container for
disposal. |
|
Waste Disposal Method |
Not considered hazardous under RCRA
(40CFR 261)
Dispose in
accordance with all applicable Federal, State and local environmental
regulations. |
|
Contains no VOCs. No special procedures
are needed for accidental release containment and clean-up. |
Section 7: Handling and
Storage
|
HANDLING: |
If handling broken
bags by hand, recommend latex gloves.
Avoid
freezing or extreme heat. |
|
STORAGE: |
Normal chemical
warehouse storage conditions acceptable.
Keep storage
container/moisture resistant packaging tightly closed. |
Section 8: Exposure
Controls/Personal Protection
|
Ventilation Requirements |
Good general mechanical ventilation and
local exhaust |
|
Specific Personal Protective Equipment |
In dusty environment (greater than 10
mg/M) wear dust masks. |
|
Eyes |
Always wear safety glasses with side
shields, if shoveling or handling broken bags, wear splash-proof
goggles. |
|
Gloves |
Impervious gloves |
|
Other |
Appropriate equipment to prevent
probability of skin and eye contact. |
Section 9: Physical and
Chemical Properties
|
Specific Gravity |
Not Applicable |
|
% Volatiles by volume |
Nil |
|
Appearance |
White bag material, ingredients are
Light Violet to Red |
|
Flash Point |
Not Applicable.
Batt-Mats
don't contain any flammable material and are treated with Fabric-Safe™
flame retardant. |
|
Solubility in Water
(% by weight) |
Not Applicable |
|
Odor |
Odorless |
Section 10: Stability and
Reactivity
|
Hazardous Polymerization |
Will not occur. |
|
Conditions to avoid |
Exposure to liquids or moisture reduces
intended absorption capability |
|
Incompatibilities |
Strong oxidizing agents.. |
|
Decomposition Products |
Carbon Monoxide. Carbon Dioxide. |
Section 11: Toxicological
Information
A skin and eye irritant. Moderately toxic by ingestion and skin contact.
Section 12: Ecological
Information
This product is not considered a hazardous waste under the RCRA.
Section 13: Disposal
Considerations
|
Aquatic Toxicity |
Not available at this time |
|
Waste Disposal Method |
Not considered hazardous under RCRA
(40CFR 261) Dispose according to state, federal and local regulations. |
Section 14: Transport
Information
This product is not
DOT regulated.
Section 15: Regulatory
Information
|
OSHA:
None. |
|
ACGIH:
None. |
|
NIOSH Criterion Document:
None. |
NFPA Hazard Rating: Health (H): None. Flammability (F): None. Reactivity (R): None
|
Section 16: Other
Information
OSHA
Occupational
Safety and Health
ACGIH
American
Conference of Governmental Industrial Hygienists
NIOSH
National
Institute for Occupational Safety and Health
NFPA
National Fire Protection Association
NTP
National Toxicology Program
